Advanced search

Report side effect

Report a suspected side effect or falsified product to the MHRA Yellow Card scheme.
Go to {yellow_card_logo} site
{arrow_up} Back to top

Sevodyne 15 microgram/hour transdermal patch

Active Ingredient:
Aspire Pharma Ltd See contact details
ATC code: 
About Medicine
{healthcare_pro_orange} This information is for use by healthcare professionals
Last updated on emc: 23 Mar 2022
1. Name of the medicinal product

Sevodyne 15 microgram/hour transdermal patch

2. Qualitative and quantitative composition

Each transdermal patch contains 15 mg of buprenorphine in a 18.75 cm² area releasing a nominal 15 micrograms of buprenorphine per hour over a period of 7 days.

For the full list of excipients, see section 6.1.

3. Pharmaceutical form

Transdermal patch

Rectangular patch beige coloured with rounded edges and imprinted with “ Buprenorphin” and “ 15 μ g/h” in blue colour.

4. Clinical particulars
4.1 Therapeutic indications

Treatment of non-malignant pain of moderate intensity when an opioid is necessary for obtaining adequate analgesia.

Sevodyne is not suitable for the treatment of acute pain.

Sevodyne is indicated in adults.

4.2 Posology and method of administration

Prior to starting treatment with opioids, a discussion should be held with patients to put in place a strategy for ending treatment with buprenorphine in order to minimise the risk of addiction and drug withdrawal syndrome (see section 4.4).


Sevodyne should be administered every 7th day.

Patients aged 18 years and over:

The lowest Sevodyne dose (Sevodyne 5 microgram/hour transdermal patch) should be used as the initial dose. Consideration should be given to the previous opioid history of the patient (see section 4.5) as well as to the current general condition and medical status of the patient.


During initiation of treatment with Sevodyne, short-acting supplemental analgesics may be required (see section 4.5) as needed until analgesic efficacy with Sevodyne is attained.

During the titration process, the dose may be adjusted every 3-days (72 hours). Thereafter, the 7-day dosing interval should be maintained. Subsequent dosage increases may then be titrated based on the need for supplemental pain relief and the patient's analgesic response to the patch.

To increase the dose, a larger patch should replace the patch that is currently being worn, or a combination of patches should be applied in different places to achieve the desired dose. It is recommended that no more than two patches are applied at the same time, up to a maximum total dose of 40 microgram/hour buprenorphine. A new patch should not be applied to the same skin site for the subsequent 3-4 weeks (see section 5.2). Patients should be carefully and regularly monitored to assess the optimum dose and duration of treatment.

In the absence of adequate pain control, the possibility of hyperalgesia, tolerance and progression of underlying disease should be considered (see section 4.4). A Sevodyne dose reduction or discontinuation of Sevodyne treatment or treatment review may be indicated.

Duration of administration

Sevodyne should under no circumstances be administered for longer than absolutely necessary. If long-term pain treatment with Sevodyne is necessary in view of the nature and severity of the illness, then careful and regular monitoring should be carried out (if necessary with breaks in treatment) to establish whether and to what extent further treatment is necessary.


After removal of the patch, buprenorphine serum concentrations decrease gradually and thus the analgesic effect is maintained for a certain amount of time. This should be considered when therapy with Sevodyne is to be followed by other opioids. As a general rule, a subsequent opioid should not be administered within 24 hours after removal of the patch. At present, only limited information is available on the starting dose of other opioids administered after discontinuation of the transdermal patch (see section 4.5).

Conversion from opioids

Sevodyne can be used as an alternative to treatment with other opioids. Such patients should be started on the lowest available dose (Sevodyne 5 microgram/hour transdermal patch) and continue taking short-acting supplemental analgesics (see section 4.5) during titration, as required.

Special populations


No dosage adjustment of Sevodyne is required in elderly patients.

Renal impairment

No special dose adjustment of Sevodyne is necessary in patients with renal impairment.

Hepatic impairment

There is no need for dosage adjustment of thus medicine in patients with mild to moderate hepatic impairment.

Buprenorphine is metabolised in the liver. The intensity and duration of its action may be affected in patients with impaired liver function. Therefore, patients with hepatic insufficiency should be carefully monitored during treatment with Sevodyne.

Patients with severe hepatic impairment may accumulate buprenorphine during Sevodyne treatment. Consideration of alternate therapy should be considered, and Sevodyne should be used with caution, if at all, in such patients.

Paediatric population

The safety and efficacy of Sevodyne in children and adolescents below 18 years of age has not been established. No data are available.

Method of administration

Sevodyne is for transdermal use.

The patch must not be divided or cut into pieces.

The patch should not be used if the seal is broken.

Patch application

In order to ensure effective analgesia of buprenorphine and to minimise the potential of skin reactions (see section 4.4), the following directions of use should be followed:

Sevodyne should be applied to non-irritated, intact skin of the upper outer arm, upper chest, upper back or the side of the chest, but not to any parts of the skin with large scars. Sevodyne should be applied to a relatively hairless or nearly hairless skin site. If none are available, the hair at the site should be cut with scissors, not shaven.

If the application site must be cleaned, it should be done with clean water only. Soaps, alcohol, oils, lotions or abrasive devices must not be used. The skin must be dry before the patch is applied. Sevodyne should be applied immediately after removal from the sealed sachet. Following removal of the protective layer, the transdermal patch should be pressed firmly in place with the palm of the hand for approximately 30 seconds, making sure the contact is complete, especially around the edges. If the edges of the patch begin to peel off, the edges may be taped down with suitable skin tape to ensure a 7 day period of wear. The patch should be worn continuously for 7 days. Bathing, showering, or swimming should not affect the patch. If a patch falls off, a new one should be applied and worn for 7 days.

4.3 Contraindications

- patients with known hypersensitivity to the active substance or to any of the excipients listed in section 6.1,

- opioid dependent patients and for narcotic withdrawal treatment,

- conditions in which the respiratory centre and function are severely impaired or may become so,

- patients who are receiving MAO inhibitors or have taken them within the last two weeks (see section 4.5)

- patients suffering from myasthenia gravis

- patients suffering from delirium tremens.

4.4 Special warnings and precautions for use

Sevodyne should be used with particular caution in patients with:

- Respiratory depression

- CNS depressants co-administration (see below and section 4.5)

- Serotonergic agents (see below and section 4.5)

- Psychological dependence [addiction], abuse profile and history of substance and/or alcohol abuse (see below)

- Sleep apnoea

- Acute alcohol intoxication

- Head injury, intracranial lesions or increased intracranial pressure, shock, a reduced level of consciousness of uncertain origin

- Severely impaired hepatic function (see section 4.2)

- Constipation

Respiratory depression

Significant respiratory depression has been associated with buprenorphine, particularly by the intravenous route. A number of overdose deaths have occurred when addicts have intravenously abused buprenorphine, usually with benzodiazepines concomitantly. Additional overdose deaths due to ethanol and benzodiazepines in combination with buprenorphine have been reported (see Section 4.9). Caution should be exercised when prescribing Sevodyne to patients known to have, or suspected of having, problems with drug or alcohol abuse or serious mental illness.

Sleep-related breathing disorders

Opioids can cause sleep-related breathing disorders including central sleep apnoea (CSA) and sleep-related hypoxemia. Opioid use increases the risk of CSA in a dose-dependent fashion. In patients who present with CSA, consider decreasing the total opioid dosage.

Patients with fever or exposed to external heat:

While wearing the patch, patients should be advised to avoid exposing the application site to external heat sources, such as heating pads, electric blankets, heat lamps, sauna, hot tubs, and heated water beds, etc., as an increase in absorption of buprenorphine may occur. When treating febrile patients, one should be aware that fever may also increase absorption resulting in increased plasma concentrations of buprenorphine and thereby increased risk of opioid reactions.

Risk from concomitant use of sedative medicines such as benzodiazepines or related drugs

Concomitant use of Sevodyne and sedative medicines such as benzodiazepines or related drugs may result in sedation, respiratory depression, coma and death. Because of these risks, concomitant prescribing with these sedative medicines should be reserved for patients for whom alternative treatment options are not possible. If a decision is made to prescribe Sevodyne concomitantly with sedative medicines, the lowest effective dose should be used, and the duration of treatment should be as short as possible.

The patients should be followed closely for signs and symptoms of respiratory depression and sedation. In this respect, it is strongly recommended to inform patients and their caregivers to be aware of these symptoms (see section 4.5).

Serotonin syndrome

Concomitant administration of Buprenorphine and other serotonergic agents, such as MAO inhibitors, selective serotonin re-uptake inhibitors (SSRIs), serotonin norepinephrine re-uptake inhibitors (SNRIs) or tricyclic antidepressants may result in serotonin syndrome, a potentially life-threatening condition (see section 4.5).

If concomitant treatment with other serotonergic agents is clinically warranted, careful observation of the patient is advised, particularly during treatment initiation and dose increases.

Symptoms of serotonin syndrome may include mental-status changes, autonomic instability, neuromuscular abnormalities, and/or gastrointestinal symptoms.

If serotonin syndrome is suspected, a dose reduction or discontinuation of therapy should be considered depending on the severity of the symptoms.

Buprenorphine is a µ -opioid agonist, acting as a full agonist with respect to analgesia and as a partial agonist with respect to its respiratory depressant properties (see section 5.1).

Drug dependence, tolerance and potential for abuse

For all patients, prolonged use of this product may lead to drug dependence (addiction), even at therapeutic doses. Incomplete tolerance is developed for some side effects like opioid induced constipation. Particularly in patients with chronic non cancer pain, it has been reported that they may not experience a meaningful amelioration in pain intensity from continuous opioid treatment in the long term.

The risks are increased in individuals with current or past history of substance misuse disorder (including alcohol misuse) or mental health disorder (e.g., major depression).

Additional support and monitoring may be necessary when prescribing for patients at risk of opioid misuse.

A comprehensive patient history should be taken to document concomitant medications, including over-the-counter medicines and medicines obtained on-line, and past and present medical and psychiatric conditions.

Patients may find that treatment is less effective with chronic use and express a need to increase the dose to obtain the same level of pain control as initially experienced. Patients may also supplement their treatment with additional pain relievers. These could be signs that the patient is developing tolerance. The risks of developing tolerance should be explained to the patient.

Overuse or misuse may result in overdose and/or death. It is important that patients only use medicines that are prescribed for them at the dose they have been prescribed and do not give this medicine to anyone else.

Patients should be closely monitored for signs of misuse, abuse, or addiction.

The clinical need for analgesic treatment should be reviewed regularly. When it is decided that there is no benefit for continuation, gradual down titration should be applied to address withdrawal symptoms.

Athletes should be aware that this medicine may cause a positive reaction to sports doping control tests.

Drug withdrawal syndrome

Prior to starting treatment with any opioids, a discussion should be held with patients to put in place a withdrawal strategy for ending treatment with buprenorphine.

Drug withdrawal syndrome may occur upon abrupt cessation of therapy or dose reduction. Withdrawal (abstinence syndrome), when it occurs, is generally mild, begins after 2 days and may last up to 2 weeks. When a patient no longer requires therapy, it is advisable to taper the dose gradually to minimise symptoms of withdrawal. Tapering from a high dose may take weeks to months.

The opioid drug withdrawal syndrome is characterised by some or all of the following: restlessness, lacrimation, rhinorrhoea, yawning, perspiration, chills, myalgia, mydriasis and palpitations. Other symptoms may also develop including irritability, agitation, anxiety, hyperkinesia, tremor, weakness, insomnia, anorexia, abdominal cramps, nausea, vomiting, diarrhoea, increased blood pressure, increased respiratory rate or heart rate.

If women use this drug during pregnancy, there is a risk that their newborn infants will experience neonatal withdrawal syndrome.


Hyperalgesia may be diagnosed if the patient on long-term opioid therapy presents with increased pain. This might be qualitatively and anatomically distinct from pain related to disease progression or to breakthrough pain resulting from development of opioid tolerance. Pain associated with hyperalgesia tends to be more diffuse than the pre-existing pain and less defined in quality. Symptoms of hyperalgesia may resolve with a reduction of opioid dose.

Skin reactions at application site

To minimise the risk of occurrence of application site skin reactions, it is important to follow the posology instructions (see section 4.2).

Application site reactions with Sevodyne are usually presented by a mild or moderate skin inflammation (contact dermatitis), and their typical appearance may include erythema, oedema, pruritus, rash, small blisters (vesicles), and painful/burning sensation at the application site. Most commonly the cause is skin irritation (irritant contact dermatitis), and these reactions resolve spontaneously after Sevodyne removal.

Patients and caregivers should be instructed accordingly to monitor the application sites for such reactions. If allergic contact dermatitis is suspected, relevant diagnostic procedures should be performed to determine if sensitisation has occurred and its actual cause (buprenorphine and/or other ingredients of the patch).

Since CYP3A4 inhibitors may increase concentrations of buprenorphine (see section 4.5), patients already treated with CYP3A4 inhibitors should have their dose of Sevodyne carefully titrated since a reduced dosage might be sufficient in these patients.

Buprenorphine is not recommended for analgesia in the immediate post-operative period or in other situations characterised by a narrow therapeutic index or a rapidly varying analgesic requirement.

Endocrine system

Opioids may influence the hypothalamic-pituitary-adrenal or – gonadal axes. Some changes that can be seen include an increase in serum prolactin, and decreases in plasma cortisol and testosterone. Clinical symptoms may be manifest from these hormonal changes.

4.5 Interaction with other medicinal products and other forms of interaction

Effect of other active substances on the pharmacokinetics of buprenorphine:

Buprenorphine is primarily metabolised by glucuronidation and to a lesser extent (about 30%) by CYP3A4.

Concomitant treatment with CYP3A4 inhibitors may lead to elevated plasma concentrations with intensified efficacy of buprenorphine.

Studies with the CYP3A4 inhibitor ketoconazole did not produce clinically relevant increases in mean maximum (Cmax) or total (AUC) buprenorphine exposure following buprenorphine with ketoconazole as compared to buprenorphine alone.

The interaction between buprenorphine and CYP3A4 enzyme inducers has not been studied.

Co-administration of buprenorphine and enzyme inducers (e.g. phenobarbital, carbamazepine, phenytoin and rifampicin) could lead to increased clearance which might result in reduced efficacy.

Reductions in hepatic blood flow induced by some general anaesthetics (e.g. halothane) and other medicinal products may result in a decreased rate of hepatic elimination of buprenorphine.

Pharmacodynamic interactions:

Buprenorphine must not be used concomitantly with MAOIs or in patients who have received MAOIs within the previous two weeks (see section 4.3).

Buprenorphine should be used cautiously when co-administered with:

• Serotonergic medicinal products, such as MAO inhibitors, selective serotonin re-uptake inhibitors (SSRIs), serotonin norepinephrine re-uptake inhibitors (SNRIs) or tricyclic antidepressants as the risk of serotonin syndrome, a potentially life-threatening condition, is increased (see section 4.4).

• Other central nervous system depressants: other opioid derivatives (analgesics and antitussives containing e.g. morphine, dextropropoxyphene, codeine, dextromethorphan or noscapine). Certain antidepressants, sedative H1-receptor antagonists, alcohol, anxiolytics, neuroleptics, clonidine and related substances. These combinations increase the CNS depressant activity.

• Sedative medicines such as benzodiazepines or related drugs as concomitant use increases the risk of sedation, respiratory depression, coma and death because of additive CNS depressant effect. The dose and duration of concomitant use should be limited (see section 4.4). Such agents include sedatives or hypnotics, general anesthetic's, other opioid analgesics, phenothiazines, centrally acting anti-emetics, benzodiazepines and alcohol.Serotonergic medicinal products, such as selective serotonin re-uptake inhibitors (SSRIs), serotonin norepinephrine re-uptake inhibitors (SNRIs) or tricyclic antidepressants as the risk of serotonin syndrome, a potentially life-threatening condition, is increased (see section 4.4).

At typical analgesic doses buprenorphine is described to function as a pure mu receptor agonist. In buprenorphine clinical studies subjects receiving full mu agonist opioids (up to 90 mg oral morphine or oral morphine equivalents per day) were transferred to buprenorphine. There were no reports of abstinence syndrome or opioid withdrawal during conversion from entry opioid to buprenorphine (see section 4.4).

Sedative medicines such as benzodiazepines or related drugs:

The concomitant use of opioids with sedative medicines such as benzodiazepines or related drugs increases the risk of sedation, respiratory depression, coma and death because of additive CNS depressant effect. The dose and duration of concomitant use should be limited (see section 4.4).

4.6 Fertility, pregnancy and lactation


There are no or limited amount of data from the use of buprenorphine in pregnant women. Studies in animals have shown reproductive toxicity (see section 5.3). The potential risk for humans is unknown.

Buprenorphine crosses the placenta and buprenorphine and the active metabolite norbuprenorphine can be detected in newborn serum, urine and meconium following in utero exposure.

Towards the end of pregnancy high doses of buprenorphine may induce respiratory depression in the neonate even after a short period of administration. Regular use during pregnancy may cause drug dependence in the foetus, leading to withdrawal symptoms in the neonate.

Therefore, buprenorphine should not be used during pregnancy and in women of childbearing potential who are not using effective contraception unless the potential benefit justifies the potential risk to the foetus.

If opioid use is required for a prolonged period in a pregnant woman, advise the patient of the risk of neonatal opioid withdrawal syndrome and ensure that appropriate treatment will be available.

Administration during labour may depress respiration in the neonate and an antidote for the child should be readily available.


Buprenorphine is excreted in human milk. Studies in rats have shown that buprenorphine may inhibit lactation. Available pharmacodynamic/toxicological data in animals has shown excretion of buprenorphine in milk (see section 5.3). A risk to the newborn/infants cannot be excluded. This medicine should be used with caution during breastfeeding.

Administration to nursing women is not recommended as buprenorphine may be secreted in breast milk and may cause respiratory depression in the infant.


No human data on the effect of buprenorphine on fertility are available. In a fertility and early embryonic development study, no effects on reproductive parameters were observed in male or female rats (see section 5.3).

4.7 Effects on ability to drive and use machines

Buprenorphine has a major influence on the ability to drive and use machines. Even when used according to instructions, buprenorphine may affect the patient's reactions to such an extent that road safety and the ability to operate machinery may be impaired. This applies particularly in the beginning of treatment and in conjunction with other centrally acting substances including alcohol, tranquillisers, sedatives and hypnotics. An individual recommendation should be given by the physician. A general restriction is not necessary in cases where a stable dose is used.

Patients who are affected and experience undesirable effects (e.g. dizziness, drowsiness, blurred vision) during treatment initiation or titration to a higher dose should not drive or use machines, for at least 24 hours after the patch has been removed.

This medicine can impair cognitive function and can affect a patient's ability to drive safely. This class of medicine is in the list of drugs included in regulations under 5a of the Road Traffic Act 1988. When prescribing this medicine, patients should be told:

• The medicine is likely to affect your ability to drive.

• Do not drive until you know how the medicine affects you.

• It is an offence to drive while you have this medicine in your body over a specified limit unless you have a defence (called the 'statutory defence').

• This defence applies when:

o The medicine has been prescribed to treat a medical or dental problem;


o You have taken it according to the instructions given by the prescriber and in the information provided with the medicine and

o It was not affecting your ability to drive safely.

4.8 Undesirable effects

Serious adverse reactions that may be associated with buprenorphine therapy in clinical use are similar to those observed with other opioid analgesics, including respiratory depression (especially when used with other CNS depressants) and hypotension (see section 4.4).

The following undesirable effects have occurred:

System organ class


Very common (≥ 1/10)

Common (≥ 1/100 to <1/10)

Uncommon (≥ 1/1000 to <1/100)

Rare (≥ 1/10,000 to <1/1000)

Very rare (<1/10,000)

Not known (cannot be estimated from the available data)

Immune system disorders


Anaphylactic reaction

Anaphylactoid reaction

Metabolic and nutritional disorders



Psychiatric disorders

Confusion, Depression, Insomnia, Nervousness, Anxiety

Affect lability, Sleep disorder, Restlessness, Agitation, Euphoric mood, Hallucinations, Decreased libido, Nightmares, Aggression

Psychotic disorder

Drug dependence, Mood swings


Nervous system disorders

Headache, Dizziness, Somnolence


Sedation, Dysgeusia, Dysarthria, Hypoaesthesia, Memory impairment, Migraine, Syncope, Abnormal co-ordination, Disturbance in attention, Paraestheia

Balance disorder, Speech disorder

Involuntary muscle contractions

Seizures, Sleep apnoea syndrome, Hyperalgesia

Eye disorders

Dry eye, Blurred vision

Visual disturbance, Eyelid oedema, Miosis

Ear and labyrinth disorders

Tinnitus, Vertigo

Ear pain

Cardiac disorders

Palpitations, Tachycardia

Angina pectoris

Vascular disorders

Hypotension, Circulatory collapse, Hypertension, Flushing

Vasodilatation, Orthostatic hypotension

Respiratory, thoracic and mediastinal disorders


Cough, Wheezing, Hiccups

Respiratory depression, Respiratory failure, Asthma aggravated, Hyperventilation, Rhinitis

Gastrointestinal disorders

Constipation, Nausea, Vomiting

Abdominal pain, Diarrhoea, Dyspepsia, Dry mouth


Dysphagia, Ileus


Hepatobiliary disorders

Biliary colic

Skin and subcutaneous tissue disorders

Pruritus, Erythema

Rash, Sweating, Exanthema

Dry skin, Urticaria,

Face oedema

Pustules, Vesicles

Contact dermatitis, Application skin discolouration

Musculoskeletal and connective tissue disorders

Muscular weakness, Arthralgia

Myalgia, Muscle spasms

Renal and urinary disorders

Urinary incontinence, Urinary retention, Urinary hesitation

Reproductive system and breast disorders

Erectile dysfunction, Sexual dysfunction

General disorders and administration site conditions

Application site reaction1

Tiredness, Asthenic conditions, Peripheral oedema

Fatigue, Pyrexia, Rigors, Oedema, Drug withdrawal syndrome, Chest pain

Influenza like illness

Neonatal drug withdrawal syndrome, Drug tolerance


Alanine aminotransferase increased, Weight decreased

Injury, poisoning and procedural complications

Accidental injury, Fall

1 Includes common signs and symptoms of contact dermatitis (irritative or allergic): erythema, oedema, pruritus, rash, vesicles, painful/burning sensation at the application site.

* In some cases delayed local allergic reactions (allergic contact dermatitis) occurred with marked signs of inflammation. Mechanical injuries during patch removal (e.g. laceration) are also possible in patients with fragile skin. Chronic inflammation may lead to long-lasting sequelae, such as post inflammatory hyper- and hypopigmentation, as well as dry and thick scaly skin lesions, which may closely resemble scars. In such cases treatment with Sevodyne should be terminated (see sections 4.3 and 4.4).

Buprenorphine has a low risk of physical dependence. After discontinuation of Sevodyne, withdrawal symptoms are unlikely. This may be due to the very slow dissociation of buprenorphine from the opioid receptors and to the gradual decrease of buprenorphine plasma concentrations (usually over a period of 30 hours after removal of the last patch). However, after long-term use of Sevodyne, withdrawal symptoms similar to those occurring during opioid withdrawal, cannot be entirely excluded. These symptoms include agitation, anxiety, nervousness, insomnia, hyperkinesia, tremor and gastrointestinal disorders.

Reporting of suspected adverse reactions

Reporting suspected adverse reactions after authorisation of the medicinal product is important. It allows continued monitoring of the benefit/risk balance of the medicinal product. Healthcare professionals are asked to report any suspected adverse reactions via the Yellow Card Scheme ( or search for MHRA Yellow Card in the Google Play or Apple App Store.

4.9 Overdose

Patients should be informed of the signs and symptoms of overdose and to ensure that family and friends are also aware of these signs and to seek immediate medical help if they occur.

Symptoms: Symptoms similar to those of other centrally acting analgesics are to be expected. These include respiratory depression, sedation, drowsiness, nausea, vomiting, cardiovascular collapse and marked miosis.

Treatment: Any patches should be removed from the patient's skin. A patent airway should be established and maintained, respiration should be assisted or controlled as indicated and adequate body temperature and fluid balance should be maintained. Oxygen, intravenous fluids, vasopressors and other supportive measures should be employed as indicated.

A specific opioid antagonist such as naloxone may reverse the effects of buprenorphine, although naloxone may be less effective in reversing the effects of buprenorphine than other µ -opioid agonists. Treatment with continuous intravenous naloxone should begin with the usual doses but high doses may be required.

5. Pharmacological properties
5.1 Pharmacodynamic properties

Pharmacotherapeutic group: Analgesics, opioids, oripavine derivatives;

ATC code: N02AE01

Buprenorphine is a μ -opioid agonist, acting as a full agonist with respect to analgesia and as a partial agonist with respect to its respiratory depressant properties. It also has antagonistic activity at the kappa opioid receptor.

Other pharmacologic effects

In vitro and animal studies indicate various effects of natural opioids, such as morphine, on components of the immune system; the clinical significance of these findings is unknown. Whether buprenorphine, a semisynthetic opioid, has immunological effects similar to morphine is unknown.

Like other opioid analgesics, buprenorphine has a potential risk of respiratory depression. However, evidence suggests that buprenorphine is a partial agonist with respect to its respiratory depressant activity and a ceiling effect has been reported following intravenous doses of greater than 2 μ g/kg. Respiratory depression appears to be a rare occurrence at therapeutic doses of the transdermal preparation [up to 40 μ g/h].

Efficacy has been demonstrated in seven pivotal phase III studies of up to 12 weeks duration in patients with non-malignant pain of various aetiologies. These included patients with moderate and severe OA and back pain. Buprenorphine demonstrated clinically significant reductions in pain scores (approximately 3 points on the BS-11 scale) and significantly greater pain control compared with placebo.

A long term, open-label extension study (n=384) has also been performed in patients with non-malignant pain. With chronic dosing, 63% of patients were maintained in pain control for 6 months, 39% of patients for 12 months, 13% of patients for 18 months and 6% for 21 months. Approximately 17% were stabilised on the 5 mg dose, 35% on the 10 mg dose and 48% on the 20 mg dose.

5.2 Pharmacokinetic properties

There is evidence of enterohepatic recirculation.

Studies in non-pregnant and pregnant rats have shown that buprenorphine passes the blood-brain and placental barriers. Concentrations in the brain (which contained only unchanged buprenorphine) after parenteral administration were 2-3 times higher than after oral administration. After intramuscular or oral administration buprenorphine apparently accumulates in the foetal gastrointestinal lumen – presumably due to biliary excretion, as enterohepatic circulation has not fully developed.

Each patch provides a steady delivery of buprenorphine for up to seven days. Steady state is achieved during the first application. After removal of buprenorphine, buprenorphine concentrations decline, decreasing approximately 50% in 12 hours (range 10– 24 h).


Following buprenorphine application, buprenorphine diffuses from the patch through the skin. In clinical pharmacology studies, the median time for “ buprenorphine 10 microgram/hour” to deliver detectable buprenorphine concentrations (25 picograms/ml) was approximately 17 hours. Analysis of residual buprenorphine in patches after 7-day use shows 15% of the original load delivered. A study of bioavailability, relative to intravenous administration, confirms that this amount is systemically absorbed. Buprenorphine concentrations remain relatively constant during the 7-day patch application.

Application site:

A study in healthy subjects demonstrated that the pharmacokinetic profile of buprenorphine delivered by buprenorphine is similar when applied to upper outer arm, upper chest, upper back or the side of the chest (midaxillary line, 5th intercostal space). The absorption varies to some extent depending on the application site and the exposure is at the most approximately 26 % higher when applied to the upper back compared to the side of the chest.

In a study of healthy subjects receiving buprenorphine repeatedly to the same site, an almost doubled exposure was seen with a 14 day rest period. For this reason, rotation of application sites is recommended, and a new patch should not be applied to the same skin site for 3-4 weeks.

In a study of healthy subjects, application of a heating pad directly on the transdermal patch caused a transient 26 - 55% increase in blood concentrations of buprenorphine. Concentrations returned to normal within 5 hours after the heat was removed. For this reason, applying direct heat sources such as hot water bottles, heat pads or electric blankets directly to the patch is not recommended. A heating pad applied to a buprenorphine site immediately after patch removal did not alter absorption from the skin depot.


Buprenorphine is approximately 96% bound to plasma proteins.

Studies of intravenous buprenorphine have shown a large volume of distribution, implying extensive distribution of buprenorphine. In a study of intravenous buprenorphine in healthy subjects, the volume of distribution at steady state was 430 l, reflecting the large volume of distribution and lipophilicity of the active substance.

Following intravenous administration, buprenorphine and its metabolites are secreted into bile, and within several minutes, distributed into the cerebrospinal fluid. Buprenorphine concentrations in the cerebrospinal fluid appear to be approximately 15% to 25% of concurrent plasma concentrations.

Biotransformation and elimination:

Buprenorphine metabolism in the skin following buprenorphine application is negligible. Following transdermal application, buprenorphine is eliminated via hepatic metabolism, with subsequent biliary excretion and renal excretion of soluble metabolites. Hepatic metabolism, through CYP3A4 and UGT1A1/1A3 enzymes, results in two primary metabolites, norbuprenorphine and buprenorphine 3-O-glucuronide, respectively. Norbuprenorphine is glucuronidated before elimination. Buprenorphine is also eliminated in the faeces. In a study in post-operative patients, the total elimination of buprenorphine was shown to be approximately 551/h.

Norbuprenorphine is the only known active metabolite of buprenorphine.

Effect of buprenorphine on the pharmacokinetics of other active substances:

Based on in vitro studies in human microsomes and hepatocytes, buprenorphine does not have the potential to inhibit metabolism catalysed by the CYP450 enzymes CYP1A2, CYP2A6 and CYP3A4 at concentrations obtained with use of buprenorphine 20μ g/h transdermal patch. The effect on metabolism catalysed by CYP2C8, CYP2C9 and CYP2C19 has not been studied.

5.3 Preclinical safety data

Systemic toxicity and dermal toxicity

In single- and repeat-dose toxicity studies in rats, rabbits, guinea pigs, dogs and minipigs, buprenorphine caused minimal or no adverse systemic events, whereas skin irritation was observed in all species examined. Toxicological data available did not indicate a sensitising potential of the additives of the transdermal patches.

Reproductive and development toxicity

No effect on fertility or general reproductive performance was observed in rats treated with buprenorphine. In embryofoetal developmental toxicity studies conducted in rats and rabbits using buprenorphine, no embryofoetal toxicity effects were observed. In a rat pre- and post-natal developmental toxicity study with buprenorphine there was pup mortality, decreased pup body weight and concomitant maternal reduced food consumption and clinical signs.


A standard battery of genotoxicity tests indicated that buprenorphine is non-genotoxic.


In long-term studies in rats and mice there was no evidence of any carcinogenic potential relevant for humans.

6. Pharmaceutical particulars
6.1 List of excipients

Adhesive matrix (containing buprenorphine):

povidone K90

levulinic acid

oleyl oleate

Poly[acrylic acid-co-butylacrylate-co-(2-ethylhexyl)acrylate-co-vinylacetate] (5:15:75:5)

Adhesive matrix (without buprenorphine):

Poly[(2-ethylhexyl)acrylate-co-glycidylmethacrylate-co-(2-hydroxyethyl)acrylate-co-vinylacetate] (68:0,15:5:27)

Separating foil between adhesive matrices with and without buprenorphine:

poly(ethylene terephthalate) film

Backing foil: polyester

Release liner: poly(ethylene terephthalate) film, siliconised

blue printing ink

6.2 Incompatibilities

Not applicable

6.3 Shelf life

21 months

6.4 Special precautions for storage

Do not store above 25° C.

6.5 Nature and contents of container

Each child-proof sachet is made of a composite layer material consisting of Paper/ PET/ PE/ Aluminium/ Poly(acrylic acid-co-ethylene) (=Surlyn). One sachet contains one transdermal patch.

Pack sizes:

Packs containing 1, 2, 3, 4, 5, 8, 10 or 12 individually sealed transdermal patches.

Not all pack sizes may be marketed.

6.6 Special precautions for disposal and other handling

When changing the patch, the used patch should be removed, the adhesive layer folded inwards on itself, and the patch disposed of safely.

7. Marketing authorisation holder

Aspire Pharma Ltd

Unit 4, Rotherbrook Court

Bedford Road



GU32 3QG

United Kingdom

8. Marketing authorisation number(s)

PL 35533/0135

9. Date of first authorisation/renewal of the authorisation


10. Date of revision of the text


Aspire Pharma Ltd
Company image
4 Rotherbrook Court, Bedford Road, Petersfield, Hampshire, GU32 3QG, UK
+44 (0)1730 231148
Medical Information Direct Line
+44 (0)1730 231148
Customer Care direct line
+44 (0)1730 231148